Thursday, January 29, 2015

NASA's Worst Week

It's a peculiar coincidence that all NASA missions that ended in the crew being killed and vehicle destroyed occurred in the same week.  

Apollo 1 burned on the pad during a test, killing Gus Grissom, Roger Chaffee and Ed White on January 27, 1967 .  It was the result of a pure oxygen atmosphere and a spark from a wiring defect. A local legend here in the shadow of the KSC is that from then until at least the beginning of the space shuttle program, as lower level managers were promoted into positions with more Go/No-Go responsibility they were taken into a private room and required to listen to the tape of the men being burned to death. 

Shuttle Challenger was destroyed on January 28, 1986 a mere 73 seconds into mission 51-L, as a flaw in the starboard solid rocket booster allowed a secondary flame to burn through supports and cause the external tank to explode.  It was the kind of cold day that we haven't had here in some years.  It has been reported that it was between 20 and 26 around the area on the morning of the launch and the O-rings used to seal the segments of the stackable solid rocket boosters were too cold to seal.  Launch wasn't until nearly noon and it had warmed somewhat, but the shuttle had never been launched at temperatures below 40 before this.  Richard Feynman famously demonstrated that cold was likely the cause during the televised Rogers Commission meetings, dropping a section of O ring compressed by a C-clamp into his iced water and noting that it had lost its resilience at that temperature.  Kevin at the Smallest Minority links to Dr. Sanity who blogs about her experience as flight surgeon for that flight.  Her column is haunting.  Go Read. 

Shuttle Columbia, the oldest surviving shuttle flying as mission STS-107, broke up on re-entry on February 1, 2003 scattering wreckage over the central southern tier of the country with most along the Texas/Louisiana line.  As details emerged about the flight, it turns out that Columbia and everyone on board had been sentenced to death at launch - they just didn't know it.  A chunk of foam had broken off the external tank during liftoff and hit the left wing's carbon composite, punching a hole in it.  There was no way a shuttle could reenter without exposing that wing to conditions that would destroy it.  They were either going to die on reentry or sit up there and run out of food, water and air.   During reentry, hot plasma worked its way into that hole, through the structure of the wing, burning through piece after piece, sensor after sensor, until the wing tore off the shuttle and tore the vehicle apart.  Local lore on this one is that the original foam recipe was changed due to environmental regulations, causing them to switch to a foam that didn't adhere or stand up to abuse as well. 

There's plenty of evidence that the crew of Challenger survived the explosion.  The crew cabin was specifically designed to be used as an escape pod, but after design, NASA decided to drop the other requirements to save weight.  The recovered cabin had clear evidence of activity: oxygen bottles being turned on, switches that require a few steps to activate being flipped.  It's doubtful they survived the impact with the ocean and some believe they passed out due to hypoxia before that. 

There's film from inside Columbia until the moment the vehicle is ripped apart by the aerodynamic forces.  I suspect the forces ripped apart their bodies just as fast.  

January 27 to February 1 is 6 days.  Not quite a full week.  Every year, there's a memorial ceremony on the Cape.  On a personal note, I remember them all.  I was a kid living in Miami when Apollo 1 burned.  I was living here and watched Challenger live on TV.  Instead of going outside to watch it as I always did, I watched it on NASA Select satellite TV.  Mrs. Graybeard was working on the cape, next door to the facility that refurbished the SRB's between flights, and was outside watching it.  It took quite a while for the shock to ease up.  I saw those spreading contrails everywhere for a long time.  Columbia happened when it was feeling routine again.  Mom had fallen and was in the hospital; we were preparing to go down to South Florida to visit and I was watching the TV waiting to hear the double sonic booms. 

Final words to Dr. Sanity:
I remember the Challenger and her crew frequently and with love. They are a part of me now. All of them represent the best within the American spirit, and always will. Since that day in 1986, I have come to see NASA as one of the greatest impediments to the Dream of space exploration; but I have never given up the Dream itself. Nor have I forgotten any of the pioneers who have died in the service of that Dream. Some day we humans will leave this small planet and joyfully play in all the corners of the cosmos.
"I have come to see NASA as one of the greatest impediments to the Dream of space exploration; but I have never given up the Dream itself."  We're in complete agreement.   



7 comments:

  1. The ET didn't explode. It broke up - the LH2 dome failed first and the SRB rotating into O2 section did the rest. What everyone calls an explosion was the autodetonation of the mixed LH2 and O2 which started within 200 milliseconds of the initial mixing.

    The ET foam was reformulated after the ban on Freon.

    28 years at jsc

    ReplyDelete
  2. Anon - thanks for the info update. The story about the Freon is what I heard. The story was the old foam bonded better to the ET and didn't shed as much.

    The STS just seemed like it was too fragile a system with those tiles providing all the protection.

    ReplyDelete
  3. I'm not a rocket scientist, just a structural engineer, so am surely speaking out of place...

    Regardless of the type of foam used on the ET, ultimately it was going to fail as it depended on adhesion rather than a mechanical connection.

    A middle ground would have been a fabric encasement alone (required to collect the wind and weight load to mechanical fasteners). On the cylindrical tank this would be similar to a sausage skin.

    I was working Kwajalein Missile Range (KMR) when the STS-107 disaster happened. There at KMR I required mechanically adhered exterior foam insulation on buildings (EIFS) because the adhered stuff does not stick, reliably, never mind the mach wind.

    ReplyDelete
  4. I "almost" went to Kwaj back around '90, but ended up turning down the offer. It definitely had a lot going for it, though.

    After the Columbia incident happened, I remember telling my wife that I had a solution to getting the foam to stay in place. Put panty hose, only one leg, over the entire External Tank. Foam and all.

    As expected, she asked the obvious question: "where would you get panty hose that big?"

    "Two words: Kim Kardashian."

    ReplyDelete
  5. RE: Apollo 1
    I read a book by one of the Grumman engineers that stated Grumman fought with NASA over the pure Oxy atmosphere, and lost. But I can't remember the name of the book.

    Of course, he was putting Grumman in the best possible light cause he worked for them at the time. But given what we've learned later, I tend to believe it.

    ReplyDelete
  6. RE: Challenger
    I'm not an engineer, but I knew that day or soon after that day that the crew survived the explosion. The different angles of film footage showed clearly that the shuttle broke up, and I knew about the crew compartment being designed as an escape pod.

    There was a lawsuit by the NY Times (I think) for the release of the audio. They won...and after they heard it nothing was published, not even a statement saying "Nothing here to hear." I'm sure it gave them all nightmares.

    ReplyDelete
  7. A bit belated, but LCB - the story about Grumman recommending against a pure O2 atmosphere is probably true. A lot of groups did, including the Soviet space agency (supposedly).

    I remember in the days after Challenger the local news was full of reports of what was being found along the beach. Lots of shuttle tiles and other debris. I distinctly remember a report of a foot being found in a shoe that floated ashore.

    ReplyDelete